Product ID:ZYGLO REMOVER ZR-10B
MSDS Date:05/02/1996
FSC:6850
NIIN:01-352-5417
Status Code:A
MSDS Number: CJJFP

Emergency Phone: 847-657-5300

Info Phone: 847-657-5300;847-657-5388(FAX)

Preparer: CHERL A ZELEZNIK

Cage: 37676

Telephone: 708-867-8000

Cage: 59042

(NONYLPHENOXY)POLYETHYLENE OXIDE;

CAS: 9016-45-9

RTECS: MD0900000

2-METHYL-2,4-PENTANEDIOL

CAS: 107-41-5

RTECS: SA0810000

LD50 LC50 Mixture:SEE INGREDIENT 1
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: CAN IRRITATE BY REMOVING NATURAL
SKIN OILS ON LONG OR REPEATED EXPOSURES. EYES: IRRITATING.
INHALATION: NOT SIGNIFICANT AT ROOM TEMPERATURE, BUT WHEN HOT,
ZR-10B VAPORS MAY CAUSE DIZZINESS AND N AUSEA. INGESTION: NOT
SIGNIFICANT IN SMALL (MOUTHFUL) AMOUNTS.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE.

First Aid:SKIN:WASH OFF W/SOAP & WATER. USE SOOTHING LOTION. EYES:RINSE
CAREFULLY UNDER UPPER & LOWER EYELIDS FOR AT LST 15 MINS USING
PLENTY OF WATER. INHAL: REMOVE TO FRESH AIR. INGEST: DO NOT INDUCE
VOMITING . ACCIDENTAL INGESTION OF SMALL MOUTHFULIS NOT EXPECTED TO
CAUSE SIGNIFICANT HARM. NOTE: IN ALL SEVERE CASES, CONTACT
PHYSICIAN IMMEDIATELY. LOCAL TELEPHONE OPERATORS CAN FURNISH NUMBER
OF REGIONAL PO ISON CONTROL CENTER.

Flash Point Method:PMCC
Flash Point:>93.3C, 200.F
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CARBON DIOXIDE, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . KEEP CONTAINERS COOL WITH WATER SPRAY. IN
USE, ZR-10B IS DISSOLVED INTO WATER, NEARLY ELIMINATING ITS ABILITY
TO BURN.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:MOP OR SWEEP UP WITH ABSORBANT.

Handling and Storage Precautions:AVOID BREATHING SPRAY MIST. AVOID EYE
CONTACT. AVOID REPEATED OR PROLONGED SKIN CONTACT.

Respiratory Protection:NONE, UNLESS APPLIED AS SPRAY. NIOSH APPROVED
RESPIRATOR WITH FILTER IF SPRAYED IN ENCLOSED UNVENTILATED SPACE.
Ventilation:NONE, UNLESS APPLIED AS SPRAY. USE WHERE VENTILATION WILL
CARRY SPRAY MIST AWAY FROM OCCUPIED AREAS.
Protective Gloves:NITRILE RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGG .
Other Protective Equipment:EYE WASH & DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA .
Supplemental Safety and Health

Boiling Pt:>196.1C, 385.F
Vapor Pres:<0.10 MM @70F
Vapor Density:HVR/AIR
Spec Gravity:0.9
pH:NEUT
Evaporation Rate & Reference:NEGLIGIBLE
Solubility in Water:100%
Appearance and Odor:PINK VISCOUS LIQUID. MILD ODOR.
Percent Volatiles by Volume:NONE

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:SOOT, OXIDES OF CARBON IF HEATED TO
COMBUSTION TEMPERATURES.

Waste Disposal Methods:AS NON-HAZARDOUS OILY WASTE, INCINERATE IT OR
SEND TO WASTE HANDLER WHO CAN BLEND IT INTO SECONDARY FUELS.
DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL REGULATIONS
. RCRA: NOT A HAZARD OUS WASTE. U.S. EPA WASTE NUMBER: NONE.

Toxicological Information:CARCINOGENICITY: CONTAINS NO KNOWN OR
SUSPECTED CARCINOGENS LISTED WITH OSHA, IARC, NTP, OR ACGIH.
THRESHOLD LIMIT VALUE: 5 MG/M3 FOR OILY MIST. WHMIS INFORMATION
(CANADA): ACCORDING TO AVILABLE INFOR MATION, THE INGREDIENTS HAVE
NOT BEEN FOUND TO SHOW REPRODUCTIVE TOXICITY, TERATOGENICITY,
MUTAGENICITY, SKIN SENSITIZATION, OR SYNERGISTIC TOXIC EFFECT WITH
OTHER MATERIALS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:NO DATA IS AVAILABLE ON ZR-10B. IT DISSOLVES INTO WATER AND
IS BIODEGRADABLE. ITS LOW VAPOR PRESSURE MAY EXEMPT IT FROM VOC
RESTRICTIONS.

Transport Information:U.S. DOT: 49 CFR 172.101 HAZARDOUS MATERIALS
TABLE. PROPER SHIPPING: NONE, NOT RESTRICTED. HAZARD CLASS OR
DIVISION: NONE. IDENTIFICATION NO: NONE. PACKING GROUP: NONE.

SARA Title III Information:NO REPORTABLE INGREDIENTS.
Federal Regulatory Information:TSCA: ALL INGREDIENTS ARE LISTED IN TSCA
INVENTORY.
State Regulatory Information:CALIFORNIA PROPOSITION 65: CONTAINS
NOTHING ON THIS LIST. WHMIS CLASS (CANADA): D-2B. NOTE: THIS MSDS
HAS BEEN PREPARED TO MEET WHMIS (CANADA) REQUIREMENTS WITH THE
EXCEPTION OF USING 16 HEADINGS.